FabDigit

Aluminum 511.0

AA 511.0 · UNS A05110

511.0 is a low-alloy Al-Mg sand casting alloy at about 4% Mg (A05110), used in the as-cast F temper at roughly 83 MPa yield, 145 MPa tensile, 3% elongation and 50 HB.

Standard cost $$

Reference datasheet — 511.0 is not in the instant-quote catalog. Upload your part and an engineer will quote it in this grade or suggest the closest stocked equivalent.

Values for the F condition

511.0 tempers and conditions

511.0 is supplied in one standard condition, F. F is the default FabDigit quotes; the values on this page are for it.

What is 511.0?

511.0 is a low-alloy Al-Mg sand casting alloy at about 4% Mg (A05110), used in the as-cast F temper at roughly 83 MPa yield, 145 MPa tensile, 3% elongation and 50 HB. Engineers select it for corrosion resistance (rated 80), high machinability (85) and a surface that polishes and anodizes better than Al-Si castings, typically in sand-cast food, dairy and architectural hardware. Fluidity is poor with a high hot-tear and oxide-film tendency, so section design must be generous, and service is limited to about 120 °C at only 3% elongation. Choose 356.0 when castability or strength govern. 511.0 has a density of 2.65 g/cm³ (0.0957 lb/in³), lighter than 90% of aluminum grades. It melts at 588°C (1,090 °F). 511.0 has a yield strength of 83 MPa (12 ksi) and a tensile strength of 145 MPa (21 ksi) — weaker than 89% of aluminum grades. Elongation at break is 3% and the elastic modulus is 71 GPa (10.3 Msi).

What is 511.0 used for?

  • food and dairy equipment
  • cooking utensils
  • architectural fittings
  • decorative hardware

Advantages

  • Good corrosion resistance — 80/100, better than 97% of aluminum grades
  • Polishes to a fine finish — 85/100, better than 96% of aluminum grades
  • Easy to machine — 85/100, better than 95% of aluminum grades

Limitations

  • Low strength — 83 MPa (12 ksi), worse than 89% of aluminum grades
  • Limited ductility — 3%, worse than 79% of aluminum grades
  • Limited service temperature — 120°C (248 °F), worse than 79% of aluminum grades

511.0 properties

Typical room-temperature values for 511.0-F; bars are the position among aluminum grades.

Physical3

511.0 has a density of 2.65 g/cm³ (0.0957 lb/in³), lighter than 90% of aluminum grades. It melts at 588°C (1,090 °F).

Density2.65 g/cm³0.1 lb/in³
Melting Point (Solidus)588°C1,090 °F
Liquidus Temperature638°C1,180 °F

Mechanical10

511.0 has a yield strength of 83 MPa (12 ksi) and a tensile strength of 145 MPa (21 ksi) — weaker than 89% of aluminum grades. Elongation at break is 3% and the elastic modulus is 71 GPa (10.3 Msi).

Elastic (Young's) Modulus71 GPa10.3 Msi
Shear Modulus26.5 GPa3.8 Msi
Bulk Modulus69 GPa10 Msi
Poisson's Ratio0.33
Tensile Strength (Ultimate)145 MPa21 ksi
Yield Strength (0.2% offset)83 MPa12 ksi
Elongation at Break3%
Shear Strength110 MPa16 ksi
Fatigue Strength (Endurance Limit)55 MPa8 ksi
Hardness, Brinell50 HB

Thermal6

511.0 is rated for continuous service to 120°C (248 °F). It conducts heat at 141 W/m·K (81.5 BTU/hr·ft·°F), better than 50% of aluminum grades. Thermal expansion is 24 µm/m·K (13.3 µin/in·°F).

Thermal Conductivity141 W/m·K81.5 BTU/hr·ft·°F
Specific Heat Capacity963 J/kg·K0.23 BTU/lb·°F
Thermal Expansion (CTE, 20–100 °C)24 µm/m·K13.3 µin/in·°F
Latent Heat of Fusion389 J/g167 BTU/lb
Max Service Temperature (continuous)120°C248 °F
Min Service Temperature-195°C-319 °F

Electrical3

511.0 conducts electricity at 36 % IACS, better than 55% of aluminum grades.

Electrical Conductivity36 % IACS
Electrical Resistivity4.8×10⁻⁸ Ω·m1.89 µΩ·in
Magnetic Responsenon-magnetic

Chemical & Environmental3

Corrosion resistance is very good (80/100), better than 97% of aluminum grades.

Galvanic Potential (seawater, vs SCE)-0.87 V
Corrosion ResistanceVery good80/100
Chemical Resistance SummaryVery good in marine/alkaline-free atmospheres, fresh and salt water, mild alkalis and many foodstuffs; attacked by strong acids, strong caustics and mercury salts; avoid prolonged >120 °C service to limit Mg-phase grain-boundary precipitation.

Sustainability4

Producing a kilogram of 511.0 takes about 175 MJ of energy and emits 11.5 kg of CO₂ — less than 92% of aluminum grades. Typical recycled content is 50%.

Embodied Energy (primary production)175 MJ/kg75,237 BTU/lb
Embodied Carbon (primary production)11.5 kg CO₂/kg
Embodied Water1,100 L/kg132 gal/lb
Typical Recycled Content50%

Manufacturability6

511.0's machinability is excellent (85/100, better than 95% of aluminum grades); weldability very good (75/100).

MachinabilityExcellent85/100
WeldabilityVery good75/100
CastabilityFair40/100
Brazeability / SolderabilityPoor20/100
PolishabilityExcellent85/100
Anodizing Responsegood — clear and decorative anodic films of good appearance; low Si/Cu content gives brighter, less grey finish than Al-Si castings

Common Calculations5

Specific Strength (UTS / density)calculated55 kN·m/kg
Specific Stiffness (E / density)calculated26.8 MN·m/kg
Modulus of Resiliencecalculated49 kJ/m³
Thermal Diffusivitycalculated55.3 mm²/s
Thermal Shock Resistance Indexcalculated12

Values are nominal handbook figures for design screening. Certified mill or lot data ships with every FabDigit order on request.

Strength versus weight in the aluminum family

Yield strength against density for every aluminum grade FabDigit runs. 511.0 is highlighted; hover a dot for its name, or open the interactive family chart.

20501002005002.22.42.62.83Density (g/cm³)Yield strength (MPa) — log scale511.0

Working with 511.0

Is 511.0 easy to machine?

Excellent — soft, non-gummy chips with sharp high-rake carbide/PCD tooling; gives clean bores and fine surface finish with minimal built-up edge.

Can 511.0 be welded?

Readily GTAW/GMAW welded with 5356 (Al-Mg) filler; preheat is unnecessary and repairs of castings are straightforward, but weld zone remains as-cast strength.

Can 511.0 be formed, bent or molded?

Sand casting only — poor fluidity and high hot-tear/oxide-film tendency require generous fillets, controlled pouring and flux/cover protection of the melt.

511.0 chemical composition (wt %)

Limits by weight percent from the governing specification, written the way the spec states them — a single maximum for impurities, a range for alloying elements, and the base element as balance. Nominal is the typical mid-range value.

ElementSpec limit (wt %)Nominal
Si0.3 – 0.70.5
Fe≤ 0.5
Cu≤ 0.15
Mn≤ 0.35
Mgprincipal alloying element3.5 – 4.54
Zn≤ 0.15
Tigrain refiner, max≤ 0.25
Others (each)≤ 0.05
Others (total)≤ 0.15
Albalance

What surface finishes work on 511.0?

Takes bright polishing and clear or dyed anodizing better than Al-Si castings; also accepts chromate/chemical conversion coats and paint with good adhesion.

Surface treatments FabDigit runs on aluminum parts — pick them in the quote configurator or call them out on the drawing. Each links to its datasheet in the surface-finish library (thickness, specs, call-out, material verdicts).

Equivalent designations

Standards and trade names that resolve to Aluminum 511.0 in FabDigit's catalog. Equivalence is nominal — check the exact specification when certification matters.

UNS
A05110

How much does 511.0 cost?

511.0 is a standard-cost aluminum ($$), cheaper than about 71% of the materials FabDigit quotes. Part price depends far more on geometry, tolerance and quantity than on the raw stock — upload a CAD file for a live quote.

511.0 — frequently asked

What is 511.0 used for?

511.0 is typically used for food and dairy equipment, cooking utensils, architectural fittings and decorative hardware. In short: best-anodizing cast aluminum; highest machinability, cast grades; corrosion-resistant Al-Mg casting.

What is the yield strength of 511.0?

511.0 has a typical yield strength of 83 MPa (12 ksi) and a tensile strength of 145 MPa (21 ksi) — weaker than 89% of aluminum grades.

Is 511.0 easy to machine?

Yes — machinability is rated excellent (85/100, better than 95% of aluminum grades). Excellent — soft, non-gummy chips with sharp high-rake carbide/PCD tooling; gives clean bores and fine surface finish with minimal built-up edge.

Can 511.0 be welded?

Yes — weldability is rated very good (75/100). Readily GTAW/GMAW welded with 5356 (Al-Mg) filler; preheat is unnecessary and repairs of castings are straightforward, but weld zone remains as-cast strength.

What surface finishes work on 511.0?

Takes bright polishing and clear or dyed anodizing better than Al-Si castings; also accepts chromate/chemical conversion coats and paint with good adhesion.

Can 511.0 be formed, bent or molded?

Sand casting only — poor fluidity and high hot-tear/oxide-film tendency require generous fillets, controlled pouring and flux/cover protection of the melt.

What is the maximum service temperature of 511.0?

511.0 is rated for continuous use to about 120°C (248 °F). Strength falls off well before that limit — check the elevated-temperature data for load-bearing parts.

How much does 511.0 cost?

511.0 is a standard-cost aluminum ($$), cheaper than about 71% of the materials FabDigit quotes. Part price depends far more on geometry, tolerance and quantity than on the raw stock — upload a CAD file for a live quote.

Sources

  1. ANSI H35.1 / Aluminum Association Designations and Chemical Composition Limits for Aluminum Alloys in the Form of Castings and Ingot ('Pink Sheets') — The Aluminum Association (2018)
  2. ASTM B26/B26M — Aluminum-Alloy Sand Castings — ASTM International (2018)
  3. ASM Handbook Vol. 2 — Properties and Selection: Nonferrous Alloys and Special-Purpose Materials — ASM International (1990)
  4. ASM Specialty Handbook: Aluminum and Aluminum Alloys — ASM International (1993)
  5. ASM Handbook Vol. 13B — Corrosion: Materials — ASM International (2005)

Property data is compiled from published supplier and standards handbooks and normalised for comparison; hardness values on non-Brinell scales are converted approximately for charting only. Manufacturability limits are FabDigit quote-engine defaults and may be relaxed by engineering review. Nothing on this page is a certification — request mill certs, CoC or material test reports with your order.